Find Us: HeNan, China

Visit Us: 24-hour service

Mail Us: [email protected]

Get A Quote

Sat Determination Of The Strenght And Properties Of Concrete Containing Quarry Dust As Fine Aggregate

2012 studied the strength and corrosion resisting properties of concrete containing quarry dust as fine aggregate along with calcium nitrate as corrosion inhibiting admixture at the dosage of 1 2 3 and 4 by weight of cement the corrosion resistance performance was determined by rapid.

Inquiry Online
  • Workability Compressive Strength And Initial Surface

    Workability Compressive Strength And Initial Surface

    Jo ukpata me ephraim ga akeke compressive strength of laterised concrete using lateritic sand and quarry dust as fine aggregate arpn j eng appl sci 71 2012 8192 jo ukpata me ephraim flexural and tensile strength properties of concrete using lateritic sand and quarry dust as fine

  • Study Of Partial Replacement Of Fine

    Study Of Partial Replacement Of Fine

    1 the compressive strength of concrete is i use of quarry dust up to 10 replacement of sand f rom 10 there is decrease in compressive strength 2 the split tensile strength concrete is increased by the use of quarry dust up to 0 replacement of fine aggrega te from 10 there is a decrease in split tensile strength

  • Durability Studies And Ndt Of High Grade Concrete

    Durability Studies And Ndt Of High Grade Concrete

    22 fine aggregate the properties of sand amp quarry dust by conducting tests according with is 2386 part1 – 1963 23 coarse aggregates crushed stone coarse aggregate conforming to is 383 – 1987 was used the values of loose and compacted bulk density values of coarse aggregates were 1600 and 1781 kgm3 24 quarry

  • Research Paper Experimental Study On Partial

    Research Paper Experimental Study On Partial

    7 msharul hameed and asssekhar properties of green concrete containing quarry rock dust and marble sludge powder as fine aggregate arpn journal of engineering and applied sciences vol4 june 2009 8 prof jayeshkumar pitroda drlbzala drfsumriagr 2012

  • pdf Iosr Journal Of Engineering iosr

    pdf Iosr Journal Of Engineering iosr

    An increase in compressive strength was observed up to 30 replacement of fine aggregates by quarry dust and there after decreasing the maximum compressive strength measured was 26 more than that of reference mix at 28 days corresponding to concrete mix containing 30 quarry dust in place of fine

  • Research Article Durability Evaluation In Concrete Using

    Research Article Durability Evaluation In Concrete Using

    And later checked for water permeability concrete mixes were casted using ordinary river sand and compared with quarry dust substituted concrete e addition of quarry dust signi cantly improved the concrete matrix properties in terms of strength and permeability resistance e addition of ne quarry dust in concrete resulted in improved matrix

  • Partial Replacement Of Cement By Quarry Dust

    Partial Replacement Of Cement By Quarry Dust

    Appraisal of artificial sand as fine aggregate in sfrc arpn journal of engineering and applied sciences vol 5 no 10 pp 34–38 2010 11 m devi and k kannan analysis of strength and corrosion resistance behavior of inhibitors in concrete containing quarry dust as fine

  • Strength Studies On Metakaolin Modified Cement Mortar With

    Strength Studies On Metakaolin Modified Cement Mortar With

    Aug 22 2013 effect of water binder ratio on compressive strength figure 4 density of mortar cubes references 1 ilangovan r n mahendran and k nagamani strength and durability properties of concrete containing quarry rock dust as fine aggregate arpn journal of engineering and applied sciences vol 3 pp 2026 may 2008

  • Comparing The Compressive And Flexural Strength Of

    Comparing The Compressive And Flexural Strength Of

    Aug 24 2017 comparing the compressive and flexural strength of concrete made with riversand and quarry dust as fine aggregate title page approval page certification dedication acknowledgement abstract table of contents list of tables list of figures chapter one 10 introduction 11 background of the study 12 statement of the problem 13

  • Paper Open Access Related Content Properties Of

    Paper Open Access Related Content Properties Of

    Bond strength determination between coconut shell aggregate concrete and steel reinforcement by pullout test yashida nadir and a sujathadevelopments in utilisation of agricultural and aquaculture byproducts as aggregate in concrete a review uchechi g eziefulathis content was downloaded from ip address 407716798 on 24122019 at

  • Experimental Studies On The Effect Of Silica Fume And

    Experimental Studies On The Effect Of Silica Fume And

    Comparative study on the feasibility of silica fume and quarry dust in determination of strength of concrete key words silica fume quarry dust concrete fine aggregate coarse aggregate tests on concrete mix design 1 introduction concrete is one of the versatile heterogeneous materials civil engineering has ever

  • Optimization Of Concrete Made With Abakaliki

    Optimization Of Concrete Made With Abakaliki

    Compressive strength durability and smooth consistency fine aggregate is an important material in the production of concrete because it affects the strength of concrete to a large extent shamin at el 2006 the quarry dust used as fine aggregate in this experiment is a waste product

  • The Effect Of Partial Replacement Of Cement

    The Effect Of Partial Replacement Of Cement

    Concluded that the specific gravity of the artificial aggregate containing fly ash and quarry dust is found to be between 19 and 25 the artificial aggregate prepared in the study belongs to normal weight aggregate the compressive strength of concrete having a water cement ratio 045

  • Use Of Saw Dust Ash As Partial Replacement For Cement

    Use Of Saw Dust Ash As Partial Replacement For Cement

    Concrete properties of selfcompacting concrete containing saw dust ash elinwa and mahmoodb 2002 it was sourced from a quarry in igbajo in nigeria fine aggregate the sand used for this research work was sourced from iree osun state nigeria the the compressive strengths of concrete reduced as the percentage sda replacement

  • Paper Open Access Related Content Effect Of Different

    Paper Open Access Related Content Effect Of Different

    Concrete strength by 34 over the strength produced by concrete with sand and gravel of 28mm maximum size also as coarse aggregates’ size increases normal concrete strength decreases the rate of fall in strength is highest with the concrete containing quarry dust as a fine aggregate however the case of laterized concrete was not

  • An Experimental Study On Uses Of Quarry Dust To Replace

    An Experimental Study On Uses Of Quarry Dust To Replace

    Crusher dust as a fine aggregate in concrete for paving blocks international journal of civil and structural engineering vol 1 no 3 p 613 2010 view at google scholar 12 r ilangovana n mahendrana and k nagamanib strength and durability properties of concrete containing quarry rock dust as fine aggregate arpn journal of

  • Experimental Investigations On Durability Characteristics

    Experimental Investigations On Durability Characteristics

    Feb 22 2016 from the test results obtained we selected the type of materials we are using which include cement brick powder coarse aggregate fine aggregate quarry dust water sulphuric acid cement ordinary portland cement of c53 grade conforming to both the requirements of is 12269 and astm c 64282 typei was

  • A Study On Performance Of Crusher Dust In Place Of

    A Study On Performance Of Crusher Dust In Place Of

    Illangovanretal20063 studied quarry dust as fine aggregate in concrete collins rj etal 19942 studied quarry dust in highway constructions in the present investigations various percentages of sands such as 10 20 etc were added to crusher dust particles and the mixes were prepared and tested for compaction

  • pdf Study On Compressive Strength Of Quarry Dust As Fine

    pdf Study On Compressive Strength Of Quarry Dust As Fine

    It is found that 40 replacement of fine aggregate by quarry dust gives maximum result in strength than normal concrete and then decreases from 50 the compressive strength is quantified for varying percentage and grades of concrete by replacement of sand with quarry

  • pdf Study On Compressive Strength Of Quarry Dust As Fine

    pdf Study On Compressive Strength Of Quarry Dust As Fine

    It is found that 40 replacement of fine aggregate by quarry dust gives maximum result in strength than normal concrete and then decreases from 50 the compressive strength is quantified

  • Durability Evaluation In Concrete Using Cracked

    Durability Evaluation In Concrete Using Cracked

    Jan 01 2013 the conventional concrete containing river sand and quarry dustsubstituted concrete were prepared for studying the strength and durability properties the desired workability of all concrete mixes was maintained using superplasticizer at a maximum dosage restricted to 25 by weight of the

  • Investigation On Mechanical Properties Of Composite

    Investigation On Mechanical Properties Of Composite

    Jan 01 2020 the concrete mix m4 50 sea sand  50 quarry dust is determined as optimum mix for complete replacement of river sand the compressive strength of m4 mix is 387   019 mpa increase in compressive strength with increase in amount quarry dust is

  • Comparing The Compressive Strengths Of Concrete Made

    Comparing The Compressive Strengths Of Concrete Made

    Nowadays development of infrastructures is becoming number one priority in the world particularly in the developing countries so there are great demands within the construction industries for river sand as fine aggregate used in the production of concrete this has created a very difficult situation the cost of river sand has increased and also there is great fear from environmentalist and

  • Influence Of Crusher Dust On The Properties

    Influence Of Crusher Dust On The Properties

    Of desired strength by replacing sand with crusher dust in cement concrete at the same time retaining its quality were prepared by replacing sand with crusher dust at 0 10 20 30 40 50 and 100 a mix proportion of 115352746 by weight was taken for concrete fresh concrete properties were evaluated through slump test and

  • Godwin Akeke

    Godwin Akeke

    Samples of concrete eg cubes were made using varying contents of laterite and quarry dust as fine aggregate the quantity of laterite was varied from 0 to 100 against quarry dust at intervals of 25 the samples were cured for specified periods and tested in the laboratory for compressive

  • Properties Of Cold Bonded Quarry Dust Coarse Aggregates

    Properties Of Cold Bonded Quarry Dust Coarse Aggregates

    Sep 01 2015 the physical properties of quarry dust are given in table 2 the specific gravity of the quarry dust is 274 and artificial aggregate made using quarry dust is therefore expected to fall under the category of normal weight aggregates the particle size distribution of the quarry dust is given in fig 1 the size of the dust particles is

  • Properties Of Cold Bonded Quarry Dust Coarse Aggregates

    Properties Of Cold Bonded Quarry Dust Coarse Aggregates

    Sep 01 2015 the use of quarry powder in the production of concrete is reported by thomas and elmahllawy the quarry sand is the coarse fraction of the quarry powder and is being used as the fine aggregate in place of river sand in concrete production the fine quarry dust fraction is commercially unused

  • Full Paper Proc Of Int Conf On Advances In Civil

    Full Paper Proc Of Int Conf On Advances In Civil

    Strength and corrosion resisting properties of concrete containing quarry dust as fine aggregate along with an organic inhibitor namely triethylamine at the dosage of 1 2 3 and 4 by weight of cement strength tests water absorption test and the durability tests were conducted and the results were compared with the natural sand

  • pdf Study On Compressive Strength Of Quarry Dust As Fine

    pdf Study On Compressive Strength Of Quarry Dust As Fine

    The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries by replacement of quarry dust the requirement of land fill area can be reduced and can also solve the problem of natural sand scarcity the availability of sand at low cost as a fine aggregate in concrete is not suitable and

  • 3 Aggregate Properties

    3 Aggregate Properties

    The crushed stone or crushed gravel aggregate make the asphalt or concrete mix somewhat difficult to place to improve the workability many mixes contain both angular and round particles the coarse aggregate particles are usually crushed stone or crushed gravel and the fine aggregate particles are usually natural

  • Experimental Study On Strength Of Concrete By

    Experimental Study On Strength Of Concrete By

    The hardened strength properties of concrete natural sand was replaced with quarry dust by three proportions ie 1020 and 30 the study was carried out on m20 grade concrete with 05 water cement ratio quarry dust can be used as fine aggregate but it has to satisfy the technical requisites like workability and

  • Strength And Durability Properties Of Concrete Containing

    Strength And Durability Properties Of Concrete Containing

    The maximum value of 2567 nmm2 for concrete made with quarry dust as fine aggregate is higher than the minimum value of 22155nmm2 for concrete made with river sand as fine

  • Properties Of Concrete With Eggshell Powder And Tyre

    Properties Of Concrete With Eggshell Powder And Tyre

    The mechanical strength of concrete was investigated for up to 90 days while durability properties were studied through water absorption and carbonation test results show that concrete with 5 eggshell powder is optimal for high mechanical properties lower water absorption and low

  • pdf Flexural And Split Tensile Strength Properties Of

    pdf Flexural And Split Tensile Strength Properties Of

    The results show that flexural strengths were 328nmm 2 for 50 laterite 50 quarry dust and 288nmm 2 for 25 laterite 75 quarry dust similarly tensile strengths were 291nmm 2 for 50

  • The Strength Behavior Of Self

    The Strength Behavior Of Self

    The strength properties such as compressive strength split tensile strength and quarry dust and silica fume also can be added to concrete as part of the total constituent system the fine aggregate contain was maintained at 45 by volume of mortar and coarse aggregate was maintained at 28 by volume of concrete the water to cement

  • Effects Of Quarry Dust As Partial Sand Replacement On

    Effects Of Quarry Dust As Partial Sand Replacement On

    This research presents the findings of experimental works in terms of mechanical properties and crack profile of cement composites containing quarry dust at different percentages as a partial sand replacement the compositions of quarry dust were varied from 10 to 20 wt and were mixed into five different ratios it was found that 045 water cement ratio was suitable to mix all proportions

  • Comparing The Effect Of Rice Husk Ash And Quarry Dust

    Comparing The Effect Of Rice Husk Ash And Quarry Dust

    This research work was experimentally carried out to investigate comparing the effects of rice husk ash rha and quarry dust on the compressive strength of concrete using local aggregates as super pozzolans at optimum replacement percentage

  • Proportional Examination Of Pf Mechanical Composition

    Proportional Examination Of Pf Mechanical Composition

    This study typical strength concrete is being made from various aggregates and their impact on various characteristics to the subsequent concrete compressive strength is the most vital property of concrete in this paper two forms of coarse aggregates washed gravel and unwashed gravel were utilized sharp sand is the fine

  • Study Of Properties Of Concrete When Its Fine Aggregate

    Study Of Properties Of Concrete When Its Fine Aggregate

    This will move a long way to cut down the amount ash wheat straw ash etc fine aggregate is replaced by of waste in our surroundings the optimum re placement saw dust ash quarry fines and glass powder etc and stage of fine aggregate with sgp is 10

  • Optimization Of Concrete Made With Abakaliki Quarry Dust

    Optimization Of Concrete Made With Abakaliki Quarry Dust

    This work is aim at removing these anomalies by the use of scheffes optimization method this optimization method can predict the compressive strength of a concrete given the mix ratios and also predict the mix ratios required to give a compressive strength for a particular concrete made by completely replacing river sand with quarry

  • Effect Of Fly Ash And Quarry Dust As A Partial

    Effect Of Fly Ash And Quarry Dust As A Partial

    To study the effect of partial replacement of fine aggregates by quarry dust and cement by fly ash on cement concrete 12 need for investigation quarry dust these residues are generally less than 1 aggregate production in the normal concrete the introduction of quarry dust for mixing is limited due to its high